制氮機常見隱患及解決方案

制氮機可分為深冷制氮、膜分離制氮和分子篩制氮3種方式，均采用物理方法從空氣中制取氮氣。瑞氣所生產的制氮機采用分子篩的方式，以碳分子篩為吸附劑，從空氣中分離出氮氣。由于制氮機屬于機械設備，在使用中如若操作不當也會產生隱患，主要分為操作不當造成的機械傷害以及氣體傷害，下面從以上兩點出發對以上問題進行詳細介紹，希望用戶在使用中可以避免以下問題的出現。

Nitrogen generator can be divided into three ways: cryogenic nitrogen generator, membrane separation nitrogen generator and molecular sieve nitrogen generator, all of which use physical methods to produce nitrogen from air. The nitrogen generator produced by Ruiqi uses molecular sieve as adsorbent to separate nitrogen from air. As the nitrogen machine belongs to mechanical equipment, improper operation in use will also produce potential safety hazards, which are mainly divided into mechanical injury and gas injury caused by improper operation. The following is a detailed introduction to the above problems from the above two points, hoping that users can avoid the following problems in use.

1、由于制氮設備的PLC有可能被誤操作啟動。在養護工作開始前，一定關閉整個制氮設備的總電源。

1. Because the PLC of nitrogen making equipment may be started by misoperation. Be sure to turn off the main power supply of the whole nitrogen making equipment before maintenance.

   
   

2、由于整個制氮系統中氣體均是帶壓的，需防止壓力氣體的加渣沖擊；在空壓機、冷干機、氣體干燥設備、制氮主機及氮氣純化裝置等設備的排氣口，請勿站人。整個系統中的連接管路必須牢固可靠密封，經過設備銷售商確認可靠，以免漏氣或造成管路破裂，發生人員傷亡或財物損壞。

2. As the gas in the whole nitrogen production system is under pressure, it is necessary to prevent the slag impact of pressure gas; do not stand at the exhaust ports of air compressor, cold dryer, gas drying equipment, nitrogen production host and nitrogen purification device. The connecting pipeline in the whole system must be firmly and reliably sealed and confirmed by the equipment seller to avoid air leakage or pipeline rupture, casualties or property damage.

3、制氮設備排放出的廢氣為濃縮氧氣，容易引起火災。須嚴禁火源。

3. The exhaust gas from nitrogen plant is concentrated oxygen, which is easy to cause fire. Fire sources must be strictly prohibited.

4、高純氮氣作為隔絕空氣或氧氣等氣體的惰性氣體，在密封環境中容易使人缺氧窒息。使用時，人員必須處于通風良好的環境中，人或動物切勿在充滿高純氮氣的密封環境中，以免發生傷亡事故。

4. As an inert gas to isolate air or oxygen, high purity nitrogen is easy to cause hypoxia and suffocation in a sealed environment. When using, personnel must be in a well ventilated environment, and people or animals must not be in a sealed environment filled with high purity nitrogen, so as to avoid casualties.

5、由于整個制氮系統中要使用380V或220V動力電源，請注意用電！非人員或未經許可和培訓的其他人員切勿擅自操作電器或擅改電路。

5. As the whole nitrogen system to use 380V or 220V power supply, please pay attention to electricity safety! Non personnel or other personnel without permission and training are not allowed to operate electrical appliances or change the circuit without authorization.